Solved: PCM Pin Layout details and Diagram for Ford Details?

PCM connector pin details.
Pin out details for engine module on ford.

Connector Pin Identification details are as follows :---

This details will explain you what Pin number in Pcm is controlling what part of the car.So as per that you can test the exact part.

1998-2000 Windstar 3.0L V6 VIN U (A/T) 104 Pin Connector


PCM Pin #	Wire Color	Circuit Description (104 Pin)	Value at Hot Idle
1	PK/OR	Shift Solenoid 2/B Control	1v, 55 mph: 12v
2 ('98-'99)	PK/LG	MIL (lamp) Control	MIL On: 1v, Off: 12v
3	OR/BK	Digital TR1 Sensor	In 'P': 0v, 55 mph: 11v
4-5	---	Not Used	---
6	DB/YL	Output Shaft Speed Sensor	0 Hz, 55 mph: 2 KHz
7-12	---	Not Used	---
13	VT	Flash EEPROM	0.1v
14	---	Not Used	---
15	PK/LB	Data Bus (-)	Digital Signals
16	TN/OR	Data Bus (+)	Digital Signals
17 ('98-'99)	LG/PK	High Speed Fan Control	Fan On: 1v, Off: 12v
18-20	---	Not Used	---
21	BK/PK	CKP (+) Sensor	518-540 Hz
22	GY/YL	CKP (-) Sensor	518-540 Hz
23	---	Not Used	---
24	BK/WT	Power Ground
25	BK	Case Ground
26	DB/LG	Coil 1 Driver (Dwell)	5°, at 55 mph: 8°
27	OR/YL	Shift Solenoid 1/A Control	12v, 55 mph: 1v
28	DB	Low Speed Fan Control	Fan On: 1v, Off: 12v
29-34	---	Not Used	---
35	RD/LG	HO2S-12 (B1 S2) Signal	0.1-1.1v
36	TN/LB	MAF Sensor Return
37	OR/BK	Transmission Fluid Temperature Sensor	2.10-2.40v
38	LG/RD	Engine Coolant Temperature Sensor	0.5-0.6v
39	GY	Intake Air Temperature Sensor	1.5-2.5v
40	DG/YL	Fuel Pump Monitor	On: 12v, Off: 0v
41	BK/YL	A/C High Pressure Switch	A/C On: 12v, off: 0v
42	---	Not Used	---
43	OR/LG	Fuel Flow Output Signal	Digital Signals
44-45	---	Not Used	---
46	LG/PK	High Speed Fan Control	Fan On: 1v, Off: 12v
47	BR/PK	VR Solenoid Control	0%, at 55 mph: 45%
48	---	Not Used	---
49	LB/BK	Digital TR2 Sensor	In 'P': 0v, 55 mph: 11v
50	WT/BK	Digital TR4 Sensor	In 'P': 0v, 55 mph: 11v
51	BK/WT	Power Ground
52	RD/LB	Coil 2 Driver (Dwell)	5°, at 55 mph: 8°
53	PK/BK	Shift Solenoid 3/C Control	12v, 55 mph: 1v
54	RD/LB	TCC Solenoid Control	0%, at 55 mph: 95%
55	Y	Keep Alive Power	12-14v
56	LG/BK	EVAP Purge Solenoid	0-10 Hz (0-100%)
57-59	---	Not Used	---
60	GY/LB	HO2S-11 (B1 S1) Signal	0.1-1.1v
61	PK/LG	HO2S-22 (B2 S2) Signal	0.1-1.1v
62	RD/PK	Fuel Tank Pressure Sensor	2.6v at 0" Hg (cap off)
63	---	Not Used	---
64	LB/YL	Transmission Range Sensor	In 'P': 0v, in O/D: 1.7v

1998-2000 Windstar 3.0L V6 VIN U (A/T) 104 Pin Connector


PCM Pin #	Wire Color	Circuit Description (104 Pin)	Value at Hot Idle
65	BR/LG	EGR DPFE Sensor Signal	0.20-1.30v
66	---	Not Used	---
67	PKWT	EVAP CV Solenoid	0-10 Hz (0-100%)
68	---	Not Used	---
69	PK/YL	A/C WOT Relay Control	On: 1v, Off: 12v
70	---	Not Used	---
71	RD	Vehicle Power	12-14v
72	---	Not Used	---
73	TN/BK	Injector 5 Control	5.0-5.2 ms
74	BR/YL	Injector 3 Control	5.0-5.2 ms
75	TN	Injector 1 Control	5.0-5.2 ms
76	BK/WT	Power Ground
77	BK/WT	Power Ground
78	PKWT	Coil 3 Driver (Dwell)	5°, at 55 mph: 8°
79	---	Not Used	---
80	LB/OR	Fuel Pump Control	On: 1v, Off: 12v
81	WT/YL	EPC Solenoid Control	9.9v (15 psi)
82	---	Not Used	---
83	WT/LB	IAC Solenoid Control	10.7v (33%)
84	GY/BK	Turbine Shaft Speed Sensor	120 Hz, 30 mph: 300 Hz
85	DB/OR	Camshaft Position Sensor	6 Hz, 55 mph: 15-20 Hz
86	TN/LG	A/C Pressure Switch Signal	Switch On: 12v (Open)
87	RD/BK	HO2S-21 (B2 S1) Signal	0.1-1.1v
88	LB/RD	MAF Sensor Signal	0.8v, 55 mph: 1.9v
89	GY/WT	TP Sensor Signal	0.9v, 55 mph: 1.2v
90	BR/WT	Reference Voltage	4.9-5.1v
91	GY/RD	Analog Signal Return
92	---	Not Used	---
93	RD/WT	HO2S-11 (B1 S1) Heater	1v, Off: 12v
94	YL/LB	HO2S-21 (B2 S1) Heater	1v, Off: 12v
95	WT/BK	HO2S-12 (B1 S2) Heater	1v, Off: 12v
96	TN/YL	HO2S-22 (B2 S2) Heater	1v, Off: 12v
97	RD	Vehicle Power	12-14v
98	---	Not Used	---
99	LG/OR	Injector 6 Control	5.0-5.2 ms
100	BR/LB	Injector 4 Control	5.0-5.2 ms
101	WT	Injector 2 Control	5.0-5.2 ms
102	---	Not Used	---
103	BK/WT	Power Ground
104	---	Not Used	---

2000 Windstar 3.8L V6 VIN 4 (A/T) 104 Pin Connector


PCM Pin #	Wire Color	Circuit Description (104 Pin)	Value at Hot Idle
1	VT/OR	Shift Solenoid 2 Control	1v, 55 mph: 12v
2	---	Not Used	---
3	OR/BK	Digital TR1 Sensor	In 'P': 0v, 55 mph: 10.7v
4-5	---	Not Used	---
6	DG/WT	Turbine Shaft Speed Sensor	43 Hz, 55 mph: 108 Hz
7	---	Not Used	---
8	OR/WT	IMRC Monitor Signal	5v, 55 mph: 5v
9-12	---	Not Used	---
13	VT	Flash EEPROM	0.1v
14	---	Not Used	---
15	PK/LB	SCP Data Bus (-)
16	TN/OR	SCP Data Bus (+)	Digital Signals
17	GN/OR	PATSIN Signal	12v
18	WT/LG	PATSOUT Signal	12v
19	---	Not Used	---
20	VT	Generator Field Signal	130 Hz (37%)
21	BK/PK	CKP (-) Sensor	390-450 Hz
22	GY/YL	CKP (+) Sensor	390-450 Hz
23	---	Not Used	---
24	BK/WT	Power Ground
25	---	Not Used	---
26	DB/LG	Coil 1 Driver (Dwell)	5°, at 55 mph: 8°
27	OR/YL	Shift Solenoid 'A' Control	12v, 55 mph: 1v
28	DB	Low Speed Fan Control	Fan On: 1v, Off: 12v
29	---	Not Used	---
30	DB/LG	Passive Antitheft Indicator Control	Indicator Off: 12v, On: 1v
31	YL/LG	Power Steering Pressure Switch	Straight: 0v, Turned: 12v
32-34	---	Not Used	---
35	RD/LG	HO2S-12 (B1 S2) Signal	0.1-1.1v
36	TN/LB	MAF Sensor Return
37	OR/BK	Transmission Fluid Temperature Sensor	2.10-2.40v
38	LG/RD	Engine Coolant Temperature Sensor	0.5-0.6v
39	GY	Intake Air Temperature Sensor	1.5-2.5v
40	DG/YL	Fuel Pump Monitor	Off: 0v, On: 12v
41	BK/YL	A/C Pressure Switch Signal	A/C On: 12v, off: 0v
42	BR	IMRC Solenoid Control	12v, 55 mph: 12v
43	---	Not Used	---
44	LG/YL	PATSTRT	0v
45	RD/PK	Generator Communication	0-130 Hz
46	LG/VT	High Speed Fan Relay Control	Relay Off: 12v, On: 1v
47	BR/PK	EGR VR Solenoid Control	0%, at 55 mph: 45%
48	---	Not Used	---
49	LG/BK	Digital TR2 Sensor	In 'P': 0v, 55 mph: 10.7v
50	WT/BK	Digital TR4 Sensor	In 'P': 0v, 55 mph: 10.7v
51	BK/WT	Power Ground
52	RD/LB	Coil 2 Driver (Dwell)	5°, at 55 mph: 8°
53	PK/BK	Shift Solenoid 'C' Control	12v, 55 mph: 1v
54	RD/LB	TCC Solenoid Control	12v (0% duty cycle)
55	RD	Direct Battery	12-14v
56	LG/BK	EVAP Canister Purge Solenoid	0-10 Hz (0-100%)
57-59	---	Not Used	---
60	GY/LB	HO2S-11 (B1 S1) Signal	0.1-1.1v
61	PK/LG	HO2S-22 (B2 S2) Signal	0.1-1.1v
62	RD/PK	Fuel Tank Pressure Sensor	2.6v at 0" Hg (cap off)
63	---	Not Used	---
64	LB/YL	Digital TR3 Sensor Signal	In 'P': 0v, in O/D: 1.7v

2000 Windstar 3.8L V6 VIN 4 (A/T) 104 Pin Connector


PCM Pin #	Wire Color	Circuit Description (104 Pin)	Value at Hot Idle
65	BR/LG	EGR DPFE Sensor Signal	0.20-1.30v
66	---	Not Used	---
67	VT/WT	EVAP CV Solenoid	0-10 Hz (0-100%)
68	---	Not Used	---
69	PK/YL	A/C WOT Relay Control	On: 1v, Off: 12v
70	---	Not Used	---
71	RD	Vehicle Power (Start-Run)	12-14v
72	---	Not Used	---
73	TN/BK	Injector 5 Control	3.0-4.0 ms
74	BR/YL	Injector 3 Control	3.0-4.0 ms
75	TN	Injector 1 Control	3.0-4.0 ms
76	BK/WT	Power Ground
77	---	Not Used	---
78	PKWT	Coil 3 Driver (Dwell)	5°, at 55 mph: 8°
79	---	Not Used	---
80	LB/OR	Fuel Pump Control	On: 1v, Off: 12v
81	WT/YL	EPC Solenoid Control	9.2v (15 psi)
82	---	Not Used	---
83	WT/LB	IAC Solenoid Control	10.7v (33%)
84	DB/YL	Output Shaft Speed Sensor	0 Hz, 55 mph: 475 Hz
85	DB/OR	Camshaft Position Sensor	6 Hz, 55 mph: 13-15 Hz
86	TN/LG	A/C Pressure Switch Signal	1v (54 psi)
87	RD/BK	HO2S-21 (B2 S1) Signal	0.1-1.1v
88	LB/RD	MAF Sensor Signal	0.8v, 55 mph: 1.8v
89	GY/WT	TP Sensor Signal	0.53-1.27v
90	BR/WT	Reference Voltage	4.9-5.1v
91	GY/RD	Sensor Ground
92	---	Not Used	---
93	RD/WT	HO2S-11 (B1 S1) Heater	1v, Off: 12v
94	YL/LB	HO2S-21 (B2 S1) Heater	1v, Off: 12v
95	WT/BK	HO2S-12 (B1 S2) Heater	1v, Off: 12v
96	TN/YL	HO2S-22 (B2 S2) Heater	1v, Off: 12v
97-98	---	Not Used	---
99	LG/OR	Injector 6 Control	3.0-4.0 ms
100	BR/LB	Injector 4 Control	3.0-4.0 ms
101	WT	Injector 2 Control	3.0-4.0 ms
102	---	Not Used	---
103	BK/WT	Power Ground
104	---	Not Used	---

2001-03 Windstar 3.8L V6 VIN 4 (A/T) 104 Pin Connector


PCM Pin #	Wire Color	Circuit Description (104 Pin)	Value at Hot Idle
1	VT/OR	Shift Solenoid 2 Control	1v, 55 mph: 12v
2	---	Not Used	---
3	OR/BK	Digital TR1 Sensor	In 'P': 0v, 55 mph: 10.7v
4-5	---	Not Used	---
6	DG/WT	Turbine Shaft Speed Sensor	43 Hz, 55 mph: 108 Hz
7	---	Not Used	---
8	OR/WT	IMRC Monitor Signal	5v, 55 mph: 5v
9-12	---	Not Used	---
13	VT	Flash EEPROM	0.1v
14	---	Not Used	---
15	PK/LB	SCP Data Bus (-)
16	TN/OR	SCP Data Bus (+)	Digital Signals
17	GY/OR	PATSIN Signal	12v
18	WT/LG	PATSOUT Signal	12v
19	---	Not Used	---
20	VT	Generator Field Signal	130 Hz (37%)
21	BK/PK	CKP (-) Sensor	390-450 Hz
22	GY/YL	CKP (+) Sensor	390-450 Hz
23	---	Not Used	---
24	BK/WT	Power Ground
25	---	Not Used	---
26	DB/LG	Coil 1 Driver (Dwell)	5°, at 55 mph: 8°
27	OR/YL	Shift Solenoid 'A' Control	12v, 55 mph: 1v
28	DB	Low Speed Fan Control	Fan On: 1v, Off: 12v
29	---	Not Used	---
30	DB/LG	Passive Antitheft Indicator Control	Indicator Off: 12v, On: 1v
31	YL/LG	Power Steering Pressure Switch	Straight: 0v, Turned: 12v
32-34	---	Not Used	---
35	RD/LG	HO2S-12 (B1 S2) Signal	0.1-1.1v
36	TN/LB	MAF Sensor Return
37	OR/BK	Transmission Fluid Temperature Sensor	2.10-2.40v
38	LG/RD	Engine Coolant Temperature Sensor	0.5-0.6v
39	GY	Intake Air Temperature Sensor	1.5-2.5v
40	DG/YL	Fuel Pump Monitor	Off: 0v, On: 12v
41	BK/YL	A/C Pressure Switch Signal	A/C On: 12v, off: 0v
42	BR	IMRC Solenoid Control	12v, 55 mph: 12v
43	---	Not Used	---
44	LG/YL	PATSTRT	0v
45	RD/PK	Generator Communication	0-130 Hz
46	LG/VT	High Speed Fan Relay Control	Relay Off: 12v, On: 1v
47	BR/PK	EGR VR Solenoid Control	0%, at 55 mph: 45%
48	---	Not Used	---
49	LG/BK	Digital TR2 Sensor	In 'P': 0v, 55 mph: 10.7v
50	WT/BK	Digital TR4 Sensor	In 'P': 0v, 55 mph: 10.7v
51	BK/WT	Power Ground
52	RD/LB	Coil 2 Driver (Dwell)	5°, at 55 mph: 8°
53	PK/BK	Shift Solenoid 'C' Control	12v, 55 mph: 1v
54	RD/LB	TCC Solenoid Control	12v (0% duty cycle)
55	RD	Direct Battery	12-14v
56	LG/BK	EVAP Canister Purge Solenoid	0-10 Hz (0-100%)
57-59	---	Not Used	---
60	GY/LB	HO2S-11 (B1 S1) Signal	0.1-1.1v
61	VT/LG	HO2S-22 (B2 S2) Signal	0.1-1.1v
62	RD/PK	Fuel Tank Pressure Sensor	2.6v at 0" Hg (cap off)
63	---	Not Used	---
64	LB/YL	Digital TR3 Sensor Signal	In 'P': 0v, in O/D: 1.7v

2001-03 Windstar 3.8L V6 VIN 4 (A/T) 104 Pin Connector


PCM Pin #	Wire Color	Circuit Description (104 Pin)	Value at Hot Idle
65	BR/LG	EGR DPFE Sensor Signal	0.95-1.05v
66	---	Not Used	---
67	VT/WT	EVAP CV Solenoid	0-10 Hz (0-100%)
68	---	Not Used	---
69	PK/YL	A/C WOT Relay Control	On: 1v, Off: 12v
70	---	Not Used	---
71	RD	Vehicle Power (Start-Run)	12-14v
72	---	Not Used	---
73	TN/BK	Injector 5 Control	3.0-4.0 ms
74	BR/YL	Injector 3 Control	3.0-4.0 ms
75	TN	Injector 1 Control	3.0-4.0 ms
76	BK/WT	Power Ground
77	---	Not Used	---
78	PKWT	Coil 3 Driver (Dwell)	5°, at 55 mph: 8°
79	---	Not Used	---
80	LB/OR	Fuel Pump Relay Control	Off: 12v, On: 1v
81	WT/YL	EPC Solenoid Control	9.2v (15 psi)
82	---	Not Used	---
83	WT/LB	IAC Solenoid Control	10.7v (33%)
84	DB/YL	Output Shaft Speed Sensor	0 Hz, 55 mph: 475 Hz
85	DB/OR	Camshaft Position Sensor	6 Hz, 55 mph: 13-15 Hz
86	TN/LG	A/C Pressure Switch Signal	1v (54 psi)
87	RD/BK	HO2S-21 (B2 S1) Signal	0.1-1.1v
88	LB/RD	MAF Sensor Signal	0.8v, 55 mph: 1.8v
89	GY/WT	TP Sensor Signal	0.53-1.27v
90	BR/WT	Reference Voltage	4.9-5.1v
91	GY/RD	Sensor Ground
92	---	Not Used	---
93	RD/WT	HO2S-11 (B1 S1) Heater	1v, Off: 12v
94	YL/LB	HO2S-21 (B2 S1) Heater	1v, Off: 12v
95	WT/BK	HO2S-12 (B1 S2) Heater	1v, Off: 12v
96	TN/YL	HO2S-22 (B2 S2) Heater	1v, Off: 12v
97-98	---	Not Used	---
99	LG/OR	Injector 6 Control	3.0-4.0 ms
100	BR/LB	Injector 4 Control	3.0-4.0 ms
101	WT	Injector 2 Control	3.0-4.0 ms
102	---	Not Used	---
103	BK/WT	Power Ground
104	---	Not Used	---

This section can be used to look up the location of a particular pin, a Wire Color or a "known good" value of a PCM circuit. To locate the PCM information for a particular vehicle, find the model, correct engine size (with VIN Code) and finally the year of the vehicle.

For example, to look up the PCM terminals for a 1999 Mustang 4.6L VIN W, and find the text string shown below:

In this example, the Fuel Level Indicator circuit is connected to Pin 12 of the 104 Pin Connector by a Yellow/White wire. The value at Hot Idle shown here is the normal value for the fuel level with the tank 1/2 full.

The "All" that appears in the Title of the table indicates the information is for both automatic and manual transmission vehicle applications.

Pin Connector Graphic

Standard Colors and Abbreviations


Abbreviation	Color	Abbreviation	Color	Abbreviation	Color
BK	Black	GY	Gray	PK	Purple
BL	Blue	GN	Green	RD	Red
BR	Brown	LG	LT Green	TN	Tan
DB	Dark Blue	OR	Orange	WT	White
DG	DK Green	PK	Pink	YL	Yellow

This details will help.

Thanks.

FOR MORE HELP GO TO: ---

Car repair guide?

http://technoanswers.blogspot.in/2012/03/car-repair-guide.html

Solved

@

Monday, March 12, 2012

PCM Pin Layout details and Diagram for Ford Details?

Car repair guide?

No comments:

Post a Comment

@